Our life teaches us the truth of being human and doing things. Some people often make a fuss about things and are not calm. However, some people can often overcome their fears, calm down and find solutions to difficulties. We need to calm down when the diesel straw gas generator set fails in the process of using the diesel straw gas generator set. Find out the cause of the unit failure and eliminate the failure. There is no need to make a fuss. You can also solve the small fault of the straw gas generator set.

1、节温器损坏

1. Thermostat damaged

秸秆气发电机组如果出现水温如过高的现象，一般是由于节温器失效的缘故，致使冷却液大循环流速减慢，需要购买新的节温器进行替换。

If the water temperature of the straw gas generator set is too high, it is generally due to the failure of the thermostat, which slows down the large circulation flow rate of the coolant, and you need to purchase a new thermostat to replace it.

2、风扇皮带开裂的解决方

2. Solution to Fan Belt Cracking

秸秆气发电机组的电扇皮带损坏，应立即停机进行替换。假如当下没有条件更行替换，能够将原电扇皮带的断口两头钻两个小孔，再用粗金属丝把断皮带衔接进来做应急运用。需求留意的是，钻孔和断面间应保存恰当的间隔，防止将孔拉裂，金属丝的接头应留在皮带的外侧，皮带不要调的过紧。假如电扇皮带损坏较严峻无法衔接，能够把绳子或布带、牛皮带用铁丝扎紧，编制成一根暂时运用的皮带。格外要留意长短和粗细应与原皮带持平，绳头应当夹在中心绑好。

If the fan belt of the straw gas generator unit is damaged, it should be stopped immediately for replacement. If there is no condition for further replacement, two small holes can be drilled at both ends of the fracture of the original fan belt, and then thick metal wire can be used to connect the broken belt for emergency use. It should be noted that proper spacing should be kept between the drilling hole and the section to prevent the hole from being pulled apart. The joint of the metal wire should be left at the outside of the belt, and the belt should not be adjusted too tightly. If the fan belt is severely damaged and cannot be connected, the rope, cloth belt and leather belt can be fastened with iron wire to form a belt for temporary use. Special attention shall be paid to the length and thickness of the belt, which shall be equal to the original belt, and the rope head shall be clamped in the center and tied.

3、散热器水管漏水

3. Radiator water pipe leaks

秸秆气发电机组的使用过程中，散热器水管内部的水温过高，外部的温度过低。或是因为秸秆气秸秆气发电机组组的震荡，很容易造成水箱的水管漏水的现象。秸秆气秸秆气发电机组组的水箱漏水可以把散烟丝放入水箱内，利用水循环的压力，来使烟丝堵塞在散热管的漏水处以便暂时运用。假如水箱散热管漏水状况较严峻，能够把漏水处剪断，再把棉花团涂上番笕者在被剪断的散热管处，再用钳子把被剪断的散热管的头部夹扁，再卷边压紧即可止住漏水状况。

During the use of the straw gas generator set, the water temperature inside the radiator pipe is too high and the external temperature is too low. Or because of the vibration of the straw gas generator set, it is easy to cause water leakage of the water tank pipe. If the water tank of the straw gas generator set leaks, the loose cut tobacco can be put into the water tank, and the pressure of water circulation can be used to block the cut tobacco at the leaking place of the radiator pipe for temporary use. If the water leakage of the radiator pipe of the water tank is serious, the water leakage can be cut off, and then the cotton ball is coated with soap at the cut radiator pipe, and then the head of the cut radiator pipe is clamped flat with pliers, and then the water leakage can be stopped by crimping and pressing.

4、水泵漏水

4. Water pump leaks

秸秆气发电机组使用铝水泵，有时会出现密封不严的现象。应当把水封平面修磨平坦，或者把水封翻转180°再安装运用。假如止推橡皮圈损坏、胀大变形、绷簧弹力缺乏、折断等，都应当予以替换，并且在安装时牢记不要将绷簧压死。

The straw gas generator set uses aluminum water pump, sometimes the seal is not tight. The plane of the water seal shall be polished flat, or the water seal shall be turned 180 ° before installation and operation. If the thrust rubber ring is damaged, swollen or deformed, or the tension spring is short of elasticity or broken, it should be replaced, and the tension spring should not be pressed to death during installation.

以上就是为大家介绍的有关炼化尾气发电机组的详细的介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以专业的态度,为您提供服务

The above is a detailed introduction to the refining tail gas generator set, and I hope it will be helpful to you. If you have any questions, please contact us. We will provide you with professional services