In the normal operation process of diesel generator set, from the selection of the unit to the installation of the diesel generator set, to the selection of oil, antifreeze and fuel oil of the diesel generator set, the service life of the diesel generator set is completely different. A normal diesel car is basically no problem to drive for ten years, and a diesel generator set is rarely driven for ten years, In essence, both of them are diesel engines that output power when the main body of the diesel engine goes out and the diesel runs out. The diesel generator set uses the diesel engine of power, which is well-known in the engine industry in China; Famous for its good quality;

柴油发电机组在正常停机的状况下如下操作：

The diesel generator set operates as follows under the condition of normal shutdown:

1）逐步降低发电机组的运用负载、断开柴油发电机组的负载开关，将转换开关转动至手动位置；

1) Gradually reduce the operating load of the generator set, disconnect the load switch of the diesel generator set, and turn the transfer switch to the manual position;

2）空载下调转速降至600-800转/分，空车运转数分钟后再推进油泵手柄中止供油，待停机后将手柄复位；

2) Reduce the speed to 600-800 RPM under no load, and then push the handle of the oil pump to stop oil supply after running empty for several minutes, and reset the handle after shutdown;

3）当环境温度小于5℃时，应将水泵及柴油机的冷却水全部放尽；

3) When the ambient temperature is less than 5 ℃, the cooling water of the water pump and diesel engine should be drained completely;

4）调速手柄放到转速低位置，电压开关放到手动位置；

4) Put the speed control handle to the low speed position and the voltage switch to the manual position;

5）短期停车可不关燃油开关，避免空气进入燃油桶，长期停车应在停车后打开燃油开关；

5) For short-term shutdown, the fuel switch can not be turned off to prevent air from entering the fuel barrel. For long-term shutdown, the fuel switch should be turned on after the shutdown;

6）长期停车的话放尽机油；

6) Drain the engine oil if parking for a long time;

二、柴油发电机组紧急停车

2、 Emergency shutdown of diesel generator set

当发电机组呈现下列状况时，紧急停机。此时应先切断负载，并立刻将喷油泵开关转到切断油路的位置，致使柴油机立刻停机；

When the generator set presents the following conditions, it will be shut down in an emergency. At this time, cut off the load first, and immediately turn the fuel injection pump switch to the position of cutting off the oil circuit, so that the diesel engine will stop immediately;

1）柴油发电机组冷却水箱温度超越99℃；

1) The temperature of cooling water tank of diesel generator set exceeds 99 ℃;

2）机组发作猛烈的敲击声，或者有冷部件损坏；

2) The unit has violent knocking sound, or cold parts are damaged;

3）气缸、活塞、调速器等运动部件卡死；

3) Cylinder, piston, governor and other moving parts are stuck;

4）发电机电压超越表中大读数时；

4) When the generator voltage exceeds the large reading in the meter;

5）发作火灾或漏电及其他自然灾祸时；

5) Fire or electricity leakage and other natural disasters;

柴油发电机组呈现异常状况时，一时间排查切勿再呈现问题停机之后，没排查到事故发作缘由二次启动机器；容易形成发电机组的二次损坏；

When the diesel generator set shows abnormal conditions, check for a time and do not show problems again. After shutdown, the machine is started again without checking the cause of the accident; It is easy to cause secondary damage to the generator set;

以上就是为大家介绍的有关天然气发电机组的详细的介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以专业的态度,为您提供服务

The above is a detailed introduction about natural gas generator set, which I hope will be helpful to you If you have any questions, please contact us We will provide you with professional service